İki aşamalı termofilik anaerobik sistemde tavuk gübresinden biyogaz üretimi: Zeolit etkisinin araştırılması
Biogas production from chicken manure in two stage thermophilic anaerobic system: Investigation of zeolite effect
- Tez No: 346138
- Danışmanlar: PROF. DR. AYŞENUR UĞURLU
- Tez Türü: Yüksek Lisans
- Konular: Çevre Mühendisliği, Environmental Engineering
- Anahtar Kelimeler: Belirtilmemiş.
- Yıl: 2013
- Dil: Türkçe
- Üniversite: Hacettepe Üniversitesi
- Enstitü: Fen Bilimleri Enstitüsü
- Ana Bilim Dalı: Çevre Mühendisliği Ana Bilim Dalı
- Bilim Dalı: Belirtilmemiş.
- Sayfa Sayısı: 141
Özet
Bu çalışmada, yumurta üretimi tesislerinden kaynaklanan tavuk atıkları ile, iki aşamalı, mezofilik asetojen ve termofilik metanojen anaerobik reaktörlerinde biyogaz üretimi ve zeolitin biyogaz üretimine etkisi araştırılmıştır. Öncelikle, ağırlıkça % 1.8 uçucu katı madde (UKM) (% 3 toplam katı madde, TKM) içeriğe sahip tavuk atıkları, sırasıyla 16, 12 ve 8 günlük hidrolik bekleme sürelerinde, tek ve iki aşamalı reaktör sitemine beslenerek biyogaz üretimlerinin karşılaştırması yapılmıştır. Buna göre en uygun hidrolik bekleme süresi (HBS) belirlenerek, iki adet iki aşamalı reaktör sisteminde, ağırlıkça % 2.3 UKM (% 3.8 TKM) ve % 5.85 UKM (% 8.25 TKM) aralığında konsantrasyona sahip tavuk atıklarından üretilen, biyogaz miktarı, biyogazın metan içeriği ve iki aşamalı reaktör sistemlerinden birine eklenen zeolitin (10, 20, 30 g/L) biyogaz ve metan üretimine, amonyum azotu konsantrasyonuna, organik asit giderimine, toplam katı madde ve uçucu katı madde giderimine etkisi araştırılmıştır. Deneyler sonucunda toz zeolitin partikül çapının 0.5 mm`den daha küçük olmasından dolayı, biyogaz ve metan üretimine, TKM, UKM ve organik asit giderimine etkisi olmadığı, ancak az da olsa amonyum azotu giderimi açısından olumlu bir etkisi olduğu gözlemlenmiştir. En yüksek biyogaz dönüşüm oranı, 549 ml/g UKM-gün olarak, ağırlıkça % 2.3 (% 3.8 TKM) içeriğine sahip atık beslenmesi esnasında olmuştur. Organik asit giderimi % 93`e kadar yükselmiştir. Amonyum azotu giderimi de 30 gr zeolit/L konsantrasyonunda % 26 olmuştur. Çalışma boyunca iki aşamalı sistemlerde üretilen biyogazın CH4 oranı % 74-82 arasında değişmiştir. Anahtar Kelimeler : Biyogaz, metan, anaerobik proses, tavuk atığı, termofilik, zeolit
Özet (Çeviri)
In this study, biogas production from chicken manure originated from egg production facility and the effect of zeolite on biogas production is investigated in a two stage (mesophilic asedogenesis and thermophilic metanogenesis) anaerobic system. First, chicken manure with 1.8 % volatile solids (VS) (3 % total solids, TS by mass) is fed to both one stage and two stage reactor at hydrolic retention time of 16, 12 and 8 days respectively and their biogas productions are compared. Thus, after determining the most appropriate hidrolic retention time (HRT), biogas production rate and methane content of produced biogas are investigated in two groups of two stage reactors which are fed with chicken manure between 2.3 % VS (3.8 % TS) and 5.85 % VS (8.25 % TS) by mass. The effects of zeolite (10, 20, 30 g/L) on biogas and methane production, ammonium nitrogen concentration, removal of organic acids, removal of total solids and volatile solids are examined that is placed in one of the two stage systems. At the end of the experiments, it is observed that powdered zeolite in the reactor, had no effect on biogas and methane production, and removal of VS and organic acid due to its particles size smaller than 0.5 mm. But it has been seen that it has a little effect on removal of ammonium nitrogen. The highest biogas production rate occured as 549 ml/g VS-d during feeding waste including 2.3 % VS (3.8 % TS). Organic acid removal improved up to 93 %. Ammonium nitrogen removal was 26 % during 30 g zeolite/L in the reactor. Along the study CH4 content of the biogas produced by two stage reactors was between 74-82 %. Keywords : Biogas, methane, anaerobic process, chicken manure, thermophilic, zeolite
Benzer Tezler
- Methane production from hydrolysis product of organic food waste and baker's yeast process wastewater
Maya üretim atıksuyu ve organik yemek atığı hidroliz ürünlerinden metan üretimi
NAZLI LERMİOĞLU
Yüksek Lisans
İngilizce
2013
Biyoteknolojiİstanbul Teknik ÜniversitesiÇevre Mühendisliği Ana Bilim Dalı
YRD. DOÇ. DR. MAHMUT ALTINBAŞ
- İki aşamalı reaktör sistemlerinde peynir altı suyundan biyohidrojen üretimi
Biohydrogen production from cheese whey in two stage reactor systems
FATOŞ TUBA ÇETİNKAYA DOKGÖZ
- Lignoselülozik içerikli biyokütle ile beslenen anaerobik çürütücülerde Clostridium thermocellum'un biyogaz üretimine etkisi
Bioaugmentation with Clostridium thermocellum in the anaerobic digestion of lignocellulosic biomass
BÜŞRA ECEM ÖNER
Yüksek Lisans
Türkçe
2017
Çevre Mühendisliğiİstanbul Teknik ÜniversitesiÇevre Mühendisliği Ana Bilim Dalı
PROF. DR. ORHAN İNCE
- Termofilik Bacillus licheniformis'ten saflaştırılan ekstrapolisakkarit'in (EPS) fizikokimyasal özelliklerinin belirlenmesi
Determination of physicochemical properties of extrapolysaccaride (eps) from thermophilic bacillus licheniformis
ÖZLEM ÇETİN
Yüksek Lisans
Türkçe
2016
BiyolojiPamukkale ÜniversitesiBiyoloji Ana Bilim Dalı
PROF. DR. NAZİME MERCAN DOĞAN
YRD. DOÇ. DR. GÜLÜMSER ACAR DOĞANLI
- Farklı yağ oranlarının ve farklı starter kültürlerin kefirin nitelikleri üzerine etkisi
The effect of different fat levels and starter cultures on properties of kefir
FİLİZ YILDIZ
Doktora
Türkçe
2009
Gıda MühendisliğiAnkara ÜniversitesiSüt Teknolojisi Ana Bilim Dalı
PROF. DR. ATİA YETİŞEMİYEN