Investigation of methane production potential of industrial sludges with domestic sludge during anaerobic digestion
Endüstriyel arıtma çamurlarının evsel çamur ile karıştırılarak anaerobik çürütücü ile metan üretim potansiyelinin belirlenmesi
- Tez No: 548468
- Danışmanlar: PROF. DR. FAİKA DİLEK SANİN, DOÇ. DR. SELİM LATİF SANİN
- Tez Türü: Yüksek Lisans
- Konular: Çevre Mühendisliği, Environmental Engineering
- Anahtar Kelimeler: Belirtilmemiş.
- Yıl: 2019
- Dil: İngilizce
- Üniversite: Orta Doğu Teknik Üniversitesi
- Enstitü: Fen Bilimleri Enstitüsü
- Ana Bilim Dalı: Çevre Mühendisliği Ana Bilim Dalı
- Bilim Dalı: Belirtilmemiş.
- Sayfa Sayısı: 133
Özet
Evsel çamurun stabilizasyonun ve biyogaz üretiminin sağlanması için anaerobik çürütücüler kurulmuştur. Fakat endüstriyel çamurlar için anaerobik çürütücülerin uygulanmasında sınırlı sayıda uygulama bulunmaktadır. Bu çalışma kapsamında, iki farklı organize sanayi bölgesinde (OSB) ve tekstil endüstrisinde üretilen çamurlar, kentsel çamur ile karıştırılarak ultrasonla ön arıtım uygulanarak ve uygulanmayarak enerji üretim potansiyeli biyokimyasal metan üretim testi ile belirlenmiştir. Çalışmada kullanılan çamurlar oranları ile birlikte sadece endüstriyel çamur (A), sadece evsel çamur (D) veya karışımlar (B: 2:1 endüstriyel: evsel; C: 1:2 endüstriyel: evsel; E: 0,5:2,5 endüstriyel: evsel) olarak belirlenmiştir. Çalışma boyunca biyogaz miktarı ve metan yüzdeleri ölçülmüştür. Reaktör işletimlerinin sonunda, toplam katı madde, toplam askıda katı madde, uçucu katı madde ve uçucu askıda katı madde giderimleri ve pH ölçülmüştür. Sadece endüstriyel çamur içeren örneklerde (reaktör A), Toplam katı madde giderimi OSB I, OSB II ve tekstil endüstrisi için sırasıyla %11, %11 ve %8 olarak belirlenmiştir. Öte yandan, uçucu katı madde giderimleri, aynı reaktörler için; %20, %20 ve %11 olarak tespit edilmiştir. KOİ giderimleri ise OSB I çamuru için %17, OSB II çamuru için %15 ve tekstil endüstrisi çamuru için %6,5 olarak belirlenmiştir. Sadece evsel çamurun anaerobik çürütücüdeki ortalama giderimleri ise %23 toplam katı madde, %46 uçucu katı madde ve %36 KOİ'dir. Birlikte çürütme reaktörleri, reaktörlerin içerdikleri çamur oranlarına göre gerçekleştirilmiştir. Birim KOİ gideriminin metan üretim miktarına oranı, reaktör A bazında bakıldığında, OSB I için 0,11 L/g, OSB II için 0,13 L/g ve tekstil endüstrisi için 0,12 L/g'dır. Endüstriyel çamurlar evsel çamur ile birlikte çürütüldüğünde biyogaz üretim potansiyeline sahiptirler. Endüstriyel çamur eklendikçe üretilen biyogaz miktarında azalma beklenenden çok olmasına rağmen sonuçlara göre, endüstriyel çamur ile evsel çamurun birlikte çürütülmesi mümkün gözükmektedir.
Özet (Çeviri)
Anaerobic digestion has been established as a sludge stabilization and biogas production method for domestic sludge. However, anaerobic digestion has limited success in industrial sludge applications. In this thesis sludge from two different Organized Industrial Districts (OIDs) and textile industry are mixed with urban wastewater sludge with and without ultrasound pretreatment to investigate their energy production potential by using BMP tests. Sludges were digested alone (A for industrial, D for domestic sludge) or in mixtures (B: 2:1 industrial: municipal; C: 1:2 industrial: municipal; E: 0.5:2.5 industrial: municipal). During the operation biogas amount and methane percentage were measured. At the end of reactor operation, removals of total solids (TS), total suspended solids (TSS), volatile solids (VS) and volatile suspended solids (VSS) as well as pH were measured. TS removal for OID I, OID II and textile sludges were found as 11%, 11%, 8%, respectively for industrial sludge samples only (reactor A). On the other hand, VS removal were found as 20%, 20%, 11%, respectively for the same reactors. COD removal for OID I, OID II and textile sludges alone were found as 17%, 15%, 6.5%, respectively. When the municipal sludge was digested its average TS, VS and COD removals were 23%, 46% and 36%, respectively. The co-digestion reactors performed in accordance with the proportion of sludge that they contained. The methane amount produced per g of COD destroyed for only the industrial sludges were 0.11 L/g, 0.13 L/g and 0.12 L/g, respectively. The industrial sludges co-digested with the domestic sludge have biogas production potentials. Even though adding industrial sludge reduced the observed biogas amount to lower than that expected, results show that it is possible to co-digest industrial sludge with municipal sludge together.
Benzer Tezler
- Investigation of biogas production potential of three different sludges after thermal hydrolysis
Üç farklı çamurun biyogaz üretim potansiyelinin termal hidroliz sonrası incelenmesi
ECE ARI AKDEMİR
Yüksek Lisans
İngilizce
2019
Çevre MühendisliğiOrta Doğu Teknik ÜniversitesiÇevre Mühendisliği Ana Bilim Dalı
PROF. DR. FAİKA DİLEK SANİN
DOÇ. DR. LATİF SELİM SANİN
- Çevresel tesislerden kaynaklanan sera gazı emisyonlarının hesaplanması
Greenhouse gases calculations from enviromental facilities
MEHMET ERDOĞAN
Yüksek Lisans
Türkçe
2015
Çevre Mühendisliğiİstanbul Teknik ÜniversitesiÇevre Mühendisliği Ana Bilim Dalı
PROF. DR. MUSTAFA SAİT YAZĞAN
- Sivas atıksu arıtma tesisi arıtma çamurlarının farklı ek besi maddeleri kullanılarak anaerobik birlikte çürütülmesinin (Codigestion) araştırılması
Investigation of codigestion of Sivas wastewater treatment plant treatment sludges by using different cosubstrates
TURGAY BİŞGİN
Doktora
Türkçe
2019
Çevre MühendisliğiSivas Cumhuriyet ÜniversitesiÇevre Mühendisliği Ana Bilim Dalı
PROF. DR. MELTEM SARIOĞLU CEBECİ
- Yüksek hızlı aktif çamur sistemlerinden oluşan fazla çamurun mezofilik çürütülmesi
Mesophilic digestion of high rate activeted sludge system excess sludge
İSA IŞIK
Yüksek Lisans
Türkçe
2017
Çevre Mühendisliğiİstanbul Teknik ÜniversitesiÇevre Mühendisliği Ana Bilim Dalı
PROF. DR. İZZET ÖZTÜRK