Ni/Zr/kıeselguhr katalizörü ile karbon dioksit metanasyonu
Methanation of carbon dioxide over supported nickel/zirconium catalyst
- Tez No: 39526
- Danışmanlar: DOÇ.DR. TUĞRUL ARMAĞAN
- Tez Türü: Doktora
- Konular: Kimya Mühendisliği, Chemical Engineering
- Anahtar Kelimeler: Belirtilmemiş.
- Yıl: 1994
- Dil: Türkçe
- Üniversite: İstanbul Teknik Üniversitesi
- Enstitü: Fen Bilimleri Enstitüsü
- Ana Bilim Dalı: Belirtilmemiş.
- Bilim Dalı: Belirtilmemiş.
- Sayfa Sayısı: 74
Özet
ÖZET Sunulan çalışmada Ni/Zr/Kieselguhr katalizörü ile C02 metanasyon kinetiği 368-508 K aralığında ve atmosfer basıncında incelendi. Tepkime hız denklemi üstel yasaya göre yazıldı ve tepkime mertebesi, C02 için n=0.6 olarak bulundu. rCÖ2=1.9xlö7£XP(-92094/l?21) C°(7o2(0-6) (l-JT) (0-^mol/kg,s Tepkime hız denklemi Langmuir-Hinshelwood mekanizmasına göre aşağıdaki şekilde oluşturuldu. 5784 SXP(-85704/J?D Pm rca =---^(mol/kg,s) C0z l+5.23x10"10 EXP(63443/J?r) Pc
Özet (Çeviri)
SUMMARY METHANATION OF CARBON DIOXIDE ÖVER SUPPORTED NICKEL/ZIRCONIUM CATALYST Methanation reactions are the final step of SNG (Substitute Natural Gas) production f rom coal. Coal is gasified by partial combustion, usually in the presence of steam. The primary reactions are: C + 1/2 02> CO(1) C + H20* CO + H2(2) When the hydrogen to carbon monoxide ratio in synthesis gas is equal to ör greater than 3, the conversion of carbon monoxide and hydrogen to methane can be described by the reaction: 3 H2 + CO f:-^---^ CH4 + H2O(3) Methane is also formed by hydrogenation of carbon oxides in two other reactions: 2 H2 + 2CO f=====^ CH4 + C02(4) 4 H2 + CO2 r=====^ CH4 + 2H20(5) However, hydrogenation of carbon dioxide, Reaction (5), does not occur in the presence of carbon monoxide. Also, Reaction (4) can be considered to be a combination of Reaction (3) and the water gas shift Reaction (6): CO + H20 ^-----^ C02 + H2 (6) IXAlthough the water gas shift reaction does not produce methane, it is an important reaction in methanation chemistry, altering the H2/CO ratio with far-reaching effects on reaction products. Formation of elemental carbon by heterogeneous decomposition of carbon monoxide during methane synthesis (Boudard reaction) is an undesired side reaction: 2 CO «======? C02 + C (7) it leads to carbon deposits and reduced the catalyst activity. Also heterogeneous decomposition of methane as the reverse reaction of methane formation from the elements can cause carbon formation: CH4 «ı======» C + 2H2 (8) From thermodynamic considerations, carbon formation by the Boudard reaction (7) can be avoided only if the CO content in the reactor feed gas does not exceed 0.1 %vol. This thermodynamic limitation is, however, unrealistic for practical systems as a great number of tests have shown. As reaction rate of CO methanation is much higher than that of the Boudard reaction, the CO hydrogenation is predominate. Residual CO concentration is so low that there is no more driving force for the Boudard reaction thus making carbon formation impossible. The heterogeneous decompositionof methane into carbon and hydrogen (8) can be neglected. First, hydrogen counteracts methane decomposition and, second, reaction velocity (8) is negligibly low. XThe idea tîıat C02 reacts by a mechanism not involving intermediate CO formation was proposed by Medsford [2]. + 2H2OH -H20+H2-H20 C0~>. H2 - C^ -.> CH20> CH3OH». OH +H2 CH2* CH4 This mechanism was further developed by Pichler [2] who proposed the following sequence: || HOH +H2+H2 C +.» C^ ->. CH20 + H20». |i“X.^^ || H ^OH O +H2 CH3OH». CH4 + H20 Vlasenko and Yuzefovich [2] conclude that the most probable scheme for the formation of CH4 from C02 and H2 appears to be öne in which the formation of complexes of a type corresponding to the enol form of formaldehyde takes place initially. 21 ] + 2e + H2 -> 2[H]~ OH 2 [H]”+ C02». [HCOOH]* 21 ] + C^ + 2e (slow) OH OH C( + H2 -* HCOH + H20 OH H-C-OH + H2> CH2 + H20 CH2 4- H2» CH4 XIIn this study, the kinetics of carbon dioxide methanation over Ni/Zr/Kieselguhr catalyst at 368-508 K and atmospheric pressure was studied. Gas mixtures of 0.23, 0.46 and 1.39 carbon dioxide %vol in hydrogen were used. Carbon dioxide was diluted with nitrogen. The kinetic studies were conducted in a integral ractor system. Hydrogen and carbon dioxide were regulated independently before mixing prior to entering the reactor. The dilution of carbon dioxide with nitrogen helped maintain isothermal conditions. The reactor was constructed 2.9 mm I.D. glass tubing, and normally about 0.2 g of catalyst was contained in the reactor between glass wool. The nickel catalyst was GIRDLER G-69 (Süd- Chemie) obtained from Perkin Elmer. The catalyst was activated in a hydrogen stream (30 cmVmin) at 623 K for 2 h before cooling to the reaction temperature. The data were recorded after minumum waiting period of 10 min. The activation of the catalyst was checked with a special run during the collection of data. Helyum was used for keeping the catalyst when it was not in use. At steady state conditions the effluent gas was analyzed with Gas Chromatograph (On line and Routine). Metan, carbon dioxide and carbon monoxide were calculated seperately in the routine analysis. Conditions of Chromatographs : 1) On line: Perkin Elmer 990, Porapak Q column, 2m, 1/8“, 60°C, F.I.D detector. 2) Routine: a- CH4 analysis: Packard 419, Activated Alumina column, 2m, 1/8”, 80°C, F.I.D detector. b- C02 analysis: Perkin Elmer F-ll, Porapak Q column, 4m, 1/8“,60°C, T.C.D. detector. c- CO analysis: Perkin Elmer 8300, Porapak Q column, 2m, 1/8”, 35°C, F.I.D. detector, Ni/Zr Catalyst. XIIThe reaction rate equation was derivated accrding to power law. The reaction order with respect to carbon dioxide was 0.6. i co^l. 9 xlOn 'EXP '{-9209 4 /RT) C°co2i0-6) (1-X) {Q-e)mol/kg. s Also, the experimental results were described as a kinetic equation known as Langmuir-Hinshelwood kinetics, as Eley-Rideal mechanisms and also as Hougen-Watson models. 57 84 £XP{-85704/i?T) PT r_n = is {mol/kg. s) c°2 1+5. 23xl0-x0 EXP {634:43 /RT) Pco It was determined that metan, higher paraffins (C2H6) and olefins (C3H6) had not effect on the reaction rate, at the other side water vapour decreased the reaction rate in an insignificant amount. According to the results of this study; during hydrogenation of carbon dioxide to methane, the formation of carbon monoxide by reverse shift reaction is negligible. There is no other hydrocarbon products except methane. In the catalyst used, in this study, Zr has no hydrogenation effect in spite of this Ni is essentially active element. In the methanation of carbon dioxide and carbon monoxide, carbon monoxide methanation is completed first. XIII
Benzer Tezler
- Investigation of wear and depth-sensing indentation behavior of thermally stabilized Fe-Ni-Zr alloys
Termal kararlı Fe-Ni-Zr alaşımlarının aşınma ve derinlik duyarlı indentasyon davranışının incelenmesi
MUSTAFA TEKİN
Yüksek Lisans
İngilizce
2017
Metalurji Mühendisliğiİstanbul Teknik ÜniversitesiMetalurji ve Malzeme Mühendisliği Ana Bilim Dalı
PROF. DR. MURAT BAYDOĞAN
DOÇ. DR. HASAN KOTAN
- Thermal stabilization and mechanical properties of nanocrystalline Fe-Ni-Zr alloys
Başlık çevirisi yok
HASAN KOTAN
Doktora
İngilizce
2013
Metalurji MühendisliğiNorth Carolina State UniversityMalzeme Bilimi ve Mühendisliği Ana Bilim Dalı
PROF. CARL C. KOCH
PROF. RONALD O. SCATTERGOOD
- Metanın kuru reformlanma reaksiyonu için yeni katalizörlerin geliştirilmesi
Development of new catalysts for dry reforming of methane
ÇİĞDEM OKUTAN
Doktora
Türkçe
2020
Kimya MühendisliğiGazi ÜniversitesiKimya Mühendisliği Ana Bilim Dalı
PROF. DR. NAİL YAŞYERLİ
DOÇ. DR. HÜSEYİN ARBAĞ
- Ethanol steam reforming with zirconia based catalysts
Etanolün zirkonyum bazlı katalizörlerle buharlı reformlanması
ARZU ARSLAN
Yüksek Lisans
İngilizce
2014
Kimya MühendisliğiOrta Doğu Teknik ÜniversitesiFen Bilimleri Ana Bilim Dalı
PROF. DR. TİMUR DOĞU
- Alkil amin boran üretimi ve dehidrojenasyon karakteristiği
Alkyl amine borane production and dehydrogenation characteristics
HATİCE BEGÜM MURATHAN