Aspir yağı esaslı farklı oleojellerin elde edilmesi ve keklerin kalitesi üzerine etkilerinin araştırılması
Obtaining different oleogels based on safflower oil and investigating the effects on the quality of cakes
- Tez No: 633331
- Danışmanlar: DR. ÖĞR. ÜYESİ AYHAN BAŞTÜRK
- Tez Türü: Yüksek Lisans
- Konular: Gıda Mühendisliği, Food Engineering
- Anahtar Kelimeler: Belirtilmemiş.
- Yıl: 2020
- Dil: Türkçe
- Üniversite: Van Yüzüncü Yıl Üniversitesi
- Enstitü: Fen Bilimleri Enstitüsü
- Ana Bilim Dalı: Gıda Mühendisliği Ana Bilim Dalı
- Bilim Dalı: Belirtilmemiş.
- Sayfa Sayısı: 108
Özet
Bu tez çalışmasında aspir yağı kullanılarak, balmumu (%3, 5, 10), pirinç kepeği mumu (%5, 7, 10), propolis mumu (%5, 7, 10) ve karnauba mumu (%4, 6, 8) oleojelatörleri ile oleojeller üretilmiştir. Üretilen oleojeller ticari şorteninge alternatif olması açısından kek yapımında kullanılmıştır. Oleojellerde yağ bağlama kapasitesi (% YBK), katı yağ içeriği (% SFC) ve kristalizasyon süresi ölçümü yapılmıştır. Oleojeller ve kontrol grubu olan şortening ile üretilen keklerde % nem miktarı, pH tayini, tekstür ve duyusal analiz uygulanmıştır. Ayrıca oleojeller ve keklerden ekstrakte edilen yağlarda ise yağ asidi kompozisyonu, serbest yağ asitliği, peroksit sayısı, konjuge dien-trien ve 3-MCPD analizleri gerçekleştirilmiştir. Oleojellerin % SFC jelatör konsantrasyonuna bağlı olarak arttığı belirlenmiştir. En iyi % YBK'ne sahip jelatör balmumu olmuştur. En kısa kristalizasyon süresi, pirinç kepeği mumunda 3 dk olarak tespit edilmiştir. Aspir yağının oleojelasyon sonrasında yağ asidi kompozisyonunda değişim olmadığı saptanmıştır. Oleojellerde toplam doymuş ve toplam doymamış yağ asidi oranları sırasıyla yaklaşık %10 ve %88 iken, ticari şorteningde bu oranlar yaklaşık %51 ve %46 olarak belirlenmiştir. Oleojel ile üretilen kekler, şortening kullanılarak üretilen kek ile karşılaştırıldığında, tekstürel ve duyusal açıdan kabul edilebilir olduğu sonucuna varılmıştır. Keklerden ekstrakte edilen yağlarda 3-MCPD'nin 0.13-1.89 mg/kg arasında, glisidil esterlerinin ise 0.27-4.31 mg/kg arasında olduğu tespit edilmiştir. Şortening ve %3 balmumu oleojeli ile üretilen keklerde glisidil esterlerine rastlanmamıştır. Sonuç olarak bu çalışma ile ticari şorteninge alternatif olarak sağlık ve beslenme açısından olumlu yönleri olan oleojeller üretilmiş ve başarılı bir şekilde kek yapımında kullanılmıştır.
Özet (Çeviri)
In this thesis, oleogels were produced using cold pressed safflower oil with beeswax (3, 5, 10), rice bran wax (5, 7, 10), propolis wax (5, 7, 10) and carnauba wax (4, 6, 8). Produced oleogels for being commercial shortening alternatives were used for making cake. Oil binding capacity (YBK), solid fat content (SFC) and crystallization time were measured in oleogels. In cakes produced with oleogels and control group shortening, moisture content, pH determination, texture and sensory analysis were applied. In addition, fatty acid composition, free fatty acidity, peroxide value, conjugated diene-triene and 3-MCPD analyzes were performed in oils extracted from cakes and oleogels. It was determined that solid fat content (SFC) of oleogels increased depending on the concentration of the gelator. The best gain fat capacity (%YBK) was gelator besswax. The fastest gelling has been in rice bran wax and it was detected in 3 minutes in the process of measurement crystallisation. It was detected that there was not any change in the fatty acid composition after safflower oil oleogelation. It was determined that when the ratio of oleogels SFA and UFA were about between 10 % and 88% , in commercial shortening this rates were about 51% and 46%. When we make a comparison between the cakes which were produced with oleogels and shortening we came to the conclusion that it was acceptable respect of the sensory and texture. In the analysis of 3-MCPD and glycidyl ester in oils extracted from cakes, it was found that 3-MCPD was between 0.13-1.89 mg/kg and glycidyl esters were between 0.27-4.31. It was not encountered any glyceride ester ın the cakes which were produced with shortening and 3 % beeswax oleogels. As a result, with this study, oleogels that have positive aspects in terms of health and nutrition were produced as an alternative to commercial shortenings and were used successfully in making cakes.
Benzer Tezler
- Aspir yağı metil ve etil esterlerinin dizel motorlarda performans, yanma ve egzoz emisyonları üzerindeki etkilerinin araştırılması
Investigation of the effects of safflower oil methyl and ethyl esters on the performance, combustion and exhaust emissions in diesel engines
MEHMET SALİH YÜKSEL
Yüksek Lisans
Türkçe
2017
EnerjiBatman ÜniversitesiMakine Mühendisliği Ana Bilim Dalı
DOÇ. DR. HÜSEYİN AYDIN
- Alkol katkılı aspir yağı biyodizelinin bir dizel motorunda kullanılabilirliğinin araştırılması
Investigation of the usability of alcohol additive aspiral oil biodiesel on a diesel engine
NURETTİN DOĞANAY
Yüksek Lisans
Türkçe
2019
Makine MühendisliğiFırat ÜniversitesiOtomotiv Mühendisliği Ana Bilim Dalı
PROF. DR. CUMALİ İLKILIÇ
- Yağlama yağı için bitkisel yağların ve esterlerinin tribolojik özelliklerinin incelenmesi
The analysis of tribological properties of the vegetable oils and esters for lubrication purpose
ÖZLEM SALMAN
Doktora
Türkçe
2011
Makine MühendisliğiSüleyman Demirel ÜniversitesiMakine Mühendisliği Ana Bilim Dalı
PROF. DR. ERTUĞRUL DURAK
- Aspir ve çay tohumu yağlarının endüstriyel amaçlı kullanımının incelenmesi
Research on the industrial use of the safflower and tea seeds
SAMET SOLAK
Yüksek Lisans
Türkçe
2015
KimyaSakarya ÜniversitesiKimya Ana Bilim Dalı
PROF. DR. MUSTAFA KÜÇÜKİSLAMOĞLU
- Türkiye'de yetiştirilen aspir tohumlarından elde edilen yağların fiziksel ve kimyasal özelliklerinin belirlenmesi
Determination of physical and chemical properties the oils obtained from safflower seed grown in Turkiye
HATİCE HANDE AKÇAR GÜZERERLER
Doktora
Türkçe
2021
Gıda MühendisliğiEge ÜniversitesiGıda Mühendisliği Ana Bilim Dalı
PROF. DR. AYTAÇ GÜMÜŞKESEN